ABSTRACT: Spectroscopic techniques have great potential to evaluate soil properties. However, there are still questions regarding the applicability of spectroscopy to analyze soil phosphorous (P) availability, especially in tropical soils with low nutrient contents. Therefore, this study evaluated the possibility to estimate P availability in soil and its pools (labile, moderately labile and non-labile) via Vis-NIR spectroscopy based on intra-field calibration. We used soils from two different locations, a plot experiment that received application of phosphate fertilizers (Field-A) and a cultivated field where a grid soil sampling was performed (Field-B). We used the technique of diffuse reflectance in the visible and near-infrared (Vis-NIR) to obtain the spectra of soil samples. Predictive modeling for P availability and labile, moderately labile and non-labile pools of P in soil were obtained via partial least squares (PLS) regression; classification modeling was performed via Soft Independent Modeling of Class Analogy (SIMCA) on three P availability levels in order to overcome the limitation on quantifying P via Vis-NIR spectroscopy. We found that isolating P contents as the only variable (Field-A), Vis-NIR spectroscopy does not allow estimating P pools in the soil. In addition, quantification of P available in the soil via predictive modeling has limitations in tropical soils. On the other hand, estimating P content in soil through classes of availability is a feasible and promising alternative.

ABSTRACT: Low efficiency of nitrogen from fertilizers is a major concern worldwide, threatening the sustainability of sugarcane production. The N use efficiency (NUE) by sugarcane can be improved by adopting better fertilizing management practices, reducing environmental impacts. This work evaluated the effects of varying N rates and time of application on stalks and sugar yield in ratoon harvested early in the crop season. The experimental design was a randomized block in a 2 × 4 factorial design and a control (no N) with five replications, including two application times (45 or 90 DAH – days after harvest) and four N rates (50, 100, 150, or 200 kg N ha−1). The time of N fertilizer application promoted differences in stalk yield, as the cumulative yield of two harvests was increased by 8 % (15 Mg ha−1) at 45 DAH when compared to the application at 90 DAH. The application performed at 45 DAH augmented sugar yield by 10 % (2.8 Mg ha−1 of sugar) in relation to 90 DAH. The N rates that promoted the highest sugarcane yield were, respectively, 122 and 144 kg N ha−1 in the first and second crop cycles. The average economical rates obtained for the first and second agricultural cycles were, respectively, 104 and 127 kg N ha−1, demonstrating that the gains by applying high amounts of fertilizers (rates above 150 kg N ha−1) may not cover the investment.

ABSTRACT: Sugarcane (saccharum spp.) in Brazil is managed on the basis of “production environments”. These “production environments” are used for many purposes, such as variety allocation, application of fertilizers and definition of the planting and harvesting periods. A quality classification is essential to ensure high economic returns. However, the classification is carried out by few and, most of the time, non-representative soil samples, showing unreal local conditions of soil spatial variability and resulting in classifications that are imprecise. One of the important tools in the precision agriculture technological package is the apparent electrical conductivity (ECa) sensors that can quickly map soil spatial variability with high-resolution and at low-cost. The aim of the present work was to show that soil ECa maps are able to assist classification of the “production environments” in sugarcane fields and rapidly and accurately reflect the yield potential. Two sugarcane fields (35 and 100 ha) were mapped with an electromagnetic induction sensor to measure soil ECa and were sampled by a dense sampling grid. The results showed that the ECa technique was able to reflect mainly the spatial variability of the clay content, evidencing regions with different yield potentials, guiding soil sampling to soil classification that is both more secure and more accurate. Furthermore, ECa allowed for more precise classification, where new “production environments”, different from those previously defined by the traditional sampling methods, were revealed. Thus, sugarcane growers will be able to allocate suitable varieties and fertilize their agricultural fields in a coherent way with higher quality, guaranteeing greater sustainability and economic return on their production.

ABSTRACT: The use of mineral phosphate fertilizers associated with organic residues can improve fertilizer use efficiency and consequently decrease their usage costs. Soil application of filter cake (FC) can provide nutrients and enhance physical quality. This study aimed to evaluate the effects of different phosphate fertilizers [rock phosphate (RP) and triple superphosphate (TSP)] applied at different rates (90 and 180 kg ha-1 P2O5) associated with filter cake (10 Mg ha-1 dry matter) on the soil phosphorus (P) fractions after two consecutive seasons of sugarcane in two distinct soils, sandy and clayey. Yield was significantly improved with FC addition in the first year in both soils, while inorganic P sources did not influence crop yield at either location and in both years. Organic and residual P forms were only slightly altered in the sandy soil. The most significant changes occurred in the labile and moderately labile P fractions in both soils. Filter cake was an effective source of nutrients for plant development, increasing the levels of soil available P and keeping it at agronomically adequate levels for up to two years, however it was not able to facilitate the P release from mineral fertilizers, irrespective of the source or rate.

ABSTRACT Retaining the mineral N in the form of NH4+ in the soil for a lengthy period is desirable for reducing losses. Furthermore, there is evidence that sugarcane prefers NH4+-N in place of NO3−-N. This study aimed firstly, to evaluate the potential of root extracts of Bracchiaria humidicola andSaccharum spontaneum, in contrast with the DCD (Dicyandiamide) inhibitor, to increase absorption of N by plants fertilized with ammonium sulfate, and secondly, to quantify the emission of N2O fluxes with the use of this inhibitor. The experiment was developed in a glasshouse in an entirely randomized design where four treatments were applied: AS) ammonium sulfate (control); AS+DCD) ammonium sulfate associated with dicyandiamide; AS+BCH) ammonium sulfate associated with root extracts ofBrachiaria humidicola; and AS+SCS) ammonium sulfate associated with root extracts of Saccharum spontaneum. Differences were observed in biomass production in plants 45 and 60 days after fertilization (DAF) and 15 and 60 days in biomass accumulation of roots. The application of AS associated with DCD synthetic inhibitor kept NO3−-N values low throughout the evaluation period, while in other treatments the concentration increased right up to the second evaluation 15 DAF. Sugarcane plants did not benefit from the increased presence of ammoniacal N promoted by DCD. The use of DCD reduced the average flux of N2O during the evaluation period compared to plants receiving AS treatments only, which was not observed when root extracts of B. humidicola and S. spontaneum were used.

ABSTRACTThe low effectiveness of nitrogen fertilizer (N) is a substantial concern that threatens global sugarcane production. The aim of the research reported in this paper was to assess the residual effect of N-fertilizer applied at sugarcane planting over four crop seasons in relation to sugarcane crop yield. Toward this end three field experiments were established in the state of São Paulo, Brazil, during February of 2005 and July of 2009, in a randomized block design with four treatments: 0, 40, 80 and 120 kg ha−1 of N applied as urea during sugarcane planting. Within each plot, a microplot was established to which 15N-labeled urea was applied. The application of N at planting increased plant cane yield in two of the three sites and sucrose content at the other, whereas the only residual effect was higher sucrose content in one of the following ratoons. The combined effect was an increase in sugar yield for three of the 11 crop seasons evaluated. Over the crop cycle of a plant cane and three ratoon crops, only 35 % of the applied N was recovered, split 75, 13, 7 and 5 % in the plant cane, first, second and third ratoons, respectively. These findings document the low efficiency of N recovery by sugarcane, which increases the risk that excessive N fertilization will reduce profitability and have an adverse effect on the environment.

A presença da palha no campo, oriunda da colheita mecanizada sem despalha a fogo, implica em mudanças no manejo da cana-de-açúcar, como na realização do cultivo mecânico da soqueira e na fertilização nitrogenada. O objetivo deste trabalho foi avaliar o desenvolvimento da cana-de-açúcar submetida aos diferentes sistemas de colheita, associado à realização ou não do cultivo mecânico, e à aplicação de doses de nitrogênio (N). O trabalho foi desenvolvido na região de Sales Oliveira, SP, em área comercial de cana-de-açúcar, com a variedade SP81-3250 (2º corte), em um Latossolo Vermelho acriférrico. O delineamento foi em blocos casualizados com parcelas subsubdivididas, em quatro repetições, em que os tratamentos principais eram os sistemas de colheita (cana crua ou cana queimada); os tratamentos secundários à realização ou não do cultivo mecânico; e os tratamentos terciários às doses de N (0, 30, 60, 90, 120 e 160 kg ha-1), usando como fonte o nitrato de amônio (33 % N). Os sistemas de colheita não diferiram para a produtividade da cana-de-açúcar (t ha-1 de cana - TCH), porém a cana queimada apresentou maior teor de sacarose (Pol) e açúcar total recuperável (ATR), sendo esse fato em razão, provavelmente, do aumento das impurezas vegetais que fazem com que a qualidade tecnológica diminua. O cultivo mecânico da soqueira após a colheita da cultura não apresentou nenhum impacto na produtividade de colmos e açúcar, indicando que essa operação pode ser desconsiderada em áreas com colheita mecânica. A aplicação de fertilizante nitrogenado aumentou a altura de colmos e TCH de forma quadrática com as doses de 88 e 144 kg ha-1 de N, proporcionando os maiores valores para essas variáveis. Para a produção de açúcar por hectare (TPH), houve aumento linear em razão da adubação nitrogenada.

The presence of trash from the mechanical harvest of green cane on sugarcane plantations promotes changes in the agricultural management, for example, in the mechanical cultural practices of ratoon cane in-between the rows and nitrogen (N) fertilization. The goal of this study was to evaluate the performance of sugarcane in different harvest systems, associated to the mechanical cultural practices in interrows and N rates. The study was carried out on a sugarcane plantation in Sales Oliveira, São Paulo, Brazil, with the sugarcane variety SP81-3250, on soil classified as Acrudox, in a randomized block design with split-split plots and four replications. The main treatments consisted of harvest systems (harvesting green cane or burnt cane), the secondary treatment consisted of the mechanical cultural practices in the interrows and the tertiary treatments were N rates (0, 30, 60, 90, 120 and 160 kg ha-1), using ammonium nitrate (33 % N) as N source. The harvest systems did not differ in sugarcane yield (tons of cane per hectare - TCH), but in burnt cane, the pol percent and total sugar recovery (TSR) were higher. This could be explained by the higher quantity of plant impurities in the harvested raw material in the system without burning, which reduces the processing quality. Mechanical cultural practices in the interrows after harvest had no effect on cane yield and sugar quality, indicating that this operation can be omitted in areas with mechanical harvesting. The application of N fertilizer at rates of 88 and 144 kg ha-1 N, respectively, increased stalk height and TCH quadratically to the highest values for these variables. For the sugar yield per hectare (in pol %), N fertilization induced a linear increase.

Mechanized sugarcane (Saccharum spp.) harvest without burning has been increasingly adopted in Brazil, increasing trash availability on the field. This study aims at showing the importance of using an integrated framework tool to assess technical and economic impacts of integral harvesting and baling trash recovery strategies and different recovery rates as well as its implications in the sugarcane production, transport and processing stages. Trash recovery using baling system presents higher costs per unit of mass of recovered trash in comparison to system in which trash is harvested and transported with sugarcane stalks (integral harvesting system). However, the integrated agricultural and industrial assessment showed that recovering trash using baling system presents better economic results (higher internal rate of return and lower ethanol production cost) than the integral harvesting system for trash recovery rates higher than 30 %. Varying trash recovery fraction, stalks productivity and mean transport distance for both integral harvesting and baling systems, sensitivity analyses showed that higher trash recovery fractions associated with higher stalks yields and long transport distances favors baling system, mainly due to the reduction of bulk load density for integral harvesting system under those conditions.

Sugarcane (Saccharum spp.) harvested without burning provides a substantial amount of remains (trash) on soil profiles which can be decomposed and release nutrients contributing to reduce fertilizer needs. The contribution of nitrogen (N) from sugarcane plant residues and fertilizer in sugarcane nutrition was assessed. Plant cane treatments were micro plots of 15N-labeled urea, sugarcane trash and root system; the last two to simulate the previous crop residues incorporated into the soil after crop renewal. For ratoons, N-ammonium nitrate (N-AN) micro plots, 150 kg ha-1 of N-AN and control (0 kg ha-1) were set up to evaluate the contribution of trash in N supply and quantify the effects of N-fertilizer on N-trash mineralization. The N balances derived from each 15N source were calculated after four crops and resulted in: 15N-urea applied at planting, 31 % was recovered by plant cane, 12 % by the following ratoons, 20 % remained in the soil and 37 % was not found in the soil-system (NOC). For crop residues 15N-trash + roots 26 % was recovered by sugarcane, 51 % remained in soil, and 23 % was NOC. N-fertilizer applied to ratoons nearly doubled the amount of N from green harvest residues recovered by sugarcane; 17 vs. 31 %. Water balances and crop evapotranspiration were correlated with 15N-sources recoveries and cumulative N recovery presented a positive correlation with evapotranspiration (2005 to 2009). The 15N balances indicated that crop residues are supplementary sources of N for sugarcane and may contribute to reduce N fertilizer needs since trash is annually added to the soil.

Due to new possibilities for using sugarcane (Saccharum spp.) trash for electricity generation, and the production of 2nd generation ethanol and others chemicals, the interest for its recovery has increased. However, the question of how much trash can be removed from sugarcane field still needs to be clarified. This study evaluated the amount of dry matter, nutrients content, structural compounds and efficiency of the enzymatic hydrolysis of the hydrothermal pretreated materials for tops and dry leaves in samples from sugarcane varieties. Tops and dry leaves present differences in nutrients content and moisture. Therefore, the amount of trash to be collected should not be simply based on percentages, but also should take into account the different fractions of the crop residues. For instance, around 80 % of N, P and K were derived from tops. Therein, the environmental indicators of the entire chain of sugarcane could be benefited because more nutrients would be recycled and less mineral fertilizers might be used for sugarcane production if tops are left on the field. Further, the tops have seven times more moisture than dry leaves and higher amounts of extractives (organic compounds of low molecular weight). Moreover, as the result of yield obtained in the pretreatment steps for dry leaves were superior to the tops and the glucose yields obtained in the enzymatic hydrolysis step were similar, it can be predicted that for second generation ethanol production, it is more viable to recover parts of the dry leaves fraction, leaving the tops on the field.

The area under mechanized sugarcane (Saccharum spp.) harvesting is expanding in Brazil, increasing the return of trash to the soil. The main questions regarding this management are: (i) after adopting unburned mechanical harvesting, how long will it take to observe decreases in fertilizer requirements, (ii) what will be the magnitude of this decrease and, (iii) the impact in the short run of removing trash for energy purposes in the nutrient cycling? This study aimed to build an N prediction model for long term assessment of the contribution of sugarcane crop residues to sugarcane nutrition and to evaluate the cycling of other nutrients derived from crop residues. Keeping crop residues over the soil will increase soil N stock and N recovery by sugarcane, reaching equilibrium after 40 years with recovery of approximately 40 kg ha-1 year-1 of N. Removing trash for energy production will decrease the potential reduction in N fertilizer requirement. Of the total nutrients in the trash, 75 % of the K2O (81 kg ha-1 year-1) and 50 % of the N (31 kg ha-1 year-1) are in the tops, indicating the importance of maintaining tops in the soil to sustain soil fertility. Because the input data employed in the simulations are representative of the conditions in Southeast Brazil, these results might not be definitive for situations not represented in the experiments used in the study, but the model produced is useful to forecast changes that occur in the soil under different trash management.

Sugarcane (Saccharum spp.) crops provide carbon (C) for soil through straw and root system decomposition. Recently, however, sugarcane producers are considering straw to be removed for electricity or second generation ethanol production. To elucidate the role of straw and root system on the carbon supply into the soil, the biomass inputs from sugarcane straw (tops and dry leaves) and from root system (rhizomes and roots) were quantified, and its contribution to provide C to the soil was estimated. Three trials were carried out in the State of Sao Paulo, Brazil, from 2006 to 2009. All sites were cultivated with the variety SP81 3250 under the green sugarcane harvest. Yearly, post-harvest sugarcane residues (tops, dry leaves, roots and rhizomes) were sampled; weighted and dried for the dry mass (DM) production to be estimated. On average, DM root system production was 4.6 Mg ha-1 year-1 (1.5 Mg C ha-1 year-1) and 11.5 Mg ha-1 year-1 (5.1 Mg C ha-1 year-1) of straw. In plant cane, 35 % of the total sugarcane DM was allocated into the root system, declining to 20 % in the third ratoon. The estimate of potential allocation of sugarcane residues to soil organic C was 1.1 t ha-1 year-1; out of which 33 % was from root system and 67 % from straw. The participation of root system should be higher if soil layer is evaluated, a deeper soil layer, if root exudates are accounted and if the period of higher production of roots is considered.

Considerar a mineralização do nitrogênio (N) da matéria orgânica do solo é questão fundamental para o manejo eficiente dos fertilizantes nitrogenados nos sistemas agrícolas. A incubação aeróbia de longa duração é o método de referência para estudos que envolvem a calibração de métodos químicos de extração, a fim de estimar o N potencialmente mineralizável do solo. Contudo, a técnica é laboriosa e de alto consumo de tempo e custo. Os objetivos deste trabalho foram determinar o N mineralizável do solo na profundidade de 0-60 cm e avaliar a possibilidade de adotar a incubação anaeróbia de curta duração no lugar da aeróbia de longa duração, para estimar a mineralização líquida de N em solos cultivados com cana-de-açúcar. Utilizaram-se cinco solos, coletados nas camadas de 0-20, 20-40 e 40-60 cm, em locais que não receberam fertilização prévia com N. As amostras de solo foram incubadas aerobiamente a 35 ºC, durante 32 semanas, e anaerobiamente (saturadas com água) a 40 ºC, por sete dias, para determinar a mineralização líquida de N do solo. Os teores de areia, silte e argila apresentaram alta correlação com os índices usados para predizer o N mineralizável. O N mineralizável do solo foi mais bem estimado na profundidade de 0-40 cm, enquanto a camada de 40-60 cm apresentou baixa mineralização líquida de N em ambos os procedimentos de incubação. Na incubação anaeróbia, estimou-se adequadamente o N mineralizável do solo, correlacionando-se com o N mineralizado acumulado e o N potencialmente mineralizável do solo, ambos obtidos por meio da incubação aeróbia. A manutenção do N-NH4+ preexistente da amostra melhorou a estimativa do N mineralizável por meio da incubação anaeróbia.

Considering nitrogen mineralization (N) of soil organic matter is a key aspect for the efficient management of N fertilizers in agricultural systems. Long-term aerobic incubation is the standard technique for calibrating the chemical extraction methods used to estimate the potentially mineralizable N in soil. However, the technique is laborious, expensive and time-consuming. In this context, the aims of this study were to determine the amount of soil mineralizable N in the 0-60 cm layer and to evaluate the use of short-term anaerobic incubation instead of long-term aerobic incubation for the estimation of net N mineralization rates in soils under sugarcane. Five soils from areas without previous N fertilization were used in the layers 0-20, 20-40 and 40-60 cm. Soil samples were aerobically incubated at 35 ºC for 32 weeks or anaerobically incubated (waterlogged) at 40 ºC for seven days to determine the net soil N mineralization. The sand, silt and clay contents were highly correlated with the indexes used for predicting mineralizable N. The 0-40 cm layer was the best sampling depth for the estimation of soil mineralizable N, while in the 40-60 cm layer net N mineralization was low in both incubation procedures. Anaerobic incubation provided reliable estimates of mineralizable N in the soil that correlated well with the indexes obtained using aerobic incubation. The inclusion of the pre-existing NH4+-N content improved the reliability of the estimate of mineralizable N obtained using anaerobic incubation.

O objetivo deste trabalho foi avaliar a produtividade agroindustrial de cana-de-açúcar (produtividades de colmos e sacarose) após sucessivas adubações nitrogenadas de cana-planta e soqueiras, em sistema de preparo reduzido. O experimento foi conduzido em Jaboticabal, SP, em um Latossolo Vermelho eutrófico durante quatro ciclos agrícolas consecutivos (março de 2005 a julho de 2009). Os tratamentos de cana-planta consistiram de doses de N-ureia (controle, 40, 80 e 120 kg ha-1 de N + 120 kg ha-1 de P2O5 e K2O no sulco de plantio). Na primeira e na segunda soqueiras, as parcelas de cana-planta foram subdivididas em tratamentos de N-nitrato de amônio (controle, 50, 100 e 150 kg ha-1 de N + 150 kg ha-1 de K2O, sobre as fileiras de cana). Na terceira soqueira, a adubação com N foi de 100 kg ha-1 em todas as parcelas, inclusive nos controles, para detectar efeitos residuais das fertilizações anteriores na produtividade do último ciclo. Os colmos de cana foram colhidos mecanicamente. Utilizou-se caminhão instrumentado com balança para avaliação da produtividade de colmos (TCH), e amostras retiradas no campo para análise da quantidade de açúcar dos colmos (TSH). As doses crescentes de N e as condições meteorológicas proporcionam respostas significativas na TCH e na TSH da cana-planta e das soqueiras, na média e na produção acumulada dos ciclos agrícolas consecutivos.

The objective of this work was to evaluate the agroindustrial production of sugarcane (millable stalks and sucrose yield) after successive nitrogen fertilizations of plant cane and ratoons in a reduced tillage system. The experiment was carried out at Jaboticabal, SP, Brazil, on a Rhodic Eutrustox soil, during four consecutive crop cycles (March 2005 to July 2009). Plant cane treatments consisted of N-urea levels (control, 40, 80, and 120 kg ha-1 N + 120 kg ha-1 P2O5 and K2O in furrow application). In the first and second ratoons, the plant cane plots were subdivided in N-ammonium nitrate treatments (control, 50, 100, and 150 kg ha-1 N + 150 kg ha-1 K2O as top dressing over rows). In the third ratoon, N fertilization was leveled to 100 kg ha-1 in all plots, including controls, to detect residual effects of previous fertilizations on the last crop's cycle. Sugarcane ratoon was mechanically harvested. A weighing truck was used to evaluate stalk yield (TCH), and samples were collected in the field for analysis of sugar content (TSH). Increasing N doses and meteorological conditions promote significant responses in TCH and TSH in cane plant and ratoons, in the average and accumulated yield of the consecutive crop cycles.

O objetivo deste trabalho foi avaliar a eficiência agronômica das fontes nitrogenadas ureia (U), nitrato de amônio (NA), sulfato de amônio (SA) e cloreto de amônio (CA) em soqueira de cana-de-açúcar colhida sem queima, bem como determinar o efeito residual dessas fontes sobre a produtividade da cultura no ano agrícola subsequente. Utilizou-se o delineamento experimental de blocos ao acaso, com quatro repetições. Os tratamentos consistiram da aplicação de 120 kg ha-1 de N a um Latossolo Vermelho distrófico, coberto por palhada resultante da colheita sem queima da primeira soqueira. Incluiu-se um tratamento de controle sem adição de N fertilizante. Para avaliar o efeito residual dos adubos nitrogenados, aplicaram-se 450 kg ha-1 do formulado 20-5-19 após o corte da cana-soca. A maior produção de colmos e de açúcar na safra 2006/2007 foi obtida com a fonte SA. Na safra 2007/2008, não foi verificado efeito residual da adubação nitrogenada e houve queda de produtividade do tratamento CA em comparação ao controle. A fonte CA, à dose de 120 kg ha-1 de N em adubação de soqueira de segundo corte, é agronomicamente tão eficiente quanto as demais fontes de N utilizadas, mas tem menor eficiência no ano agrícola subsequente.

The objective of this work was to evaluate the agronomic efficiency of the nitrogen sources urea (U), ammonium nitrate (AN), ammonium sulfate (AS), and ammonium chloride (AC) on green harvesting sugarcane ratoon, as well as the residual effect of these sources on crop productivity in the subsequent crop year. A randomized block design was used with four replicates. Treatments consisted of applying 120 kg ha-1 of N fertilizer on a Typic Hapludox covered by straw residues resulting from the harvest without burning of the first ratoon. A control treatment was included with no N fertilizer. To evaluate the residual effect of the nitrogen fertilizers, 450 kg ha-1 of a 20-5-19 formulation was applied to soil after sugarcane ratoon harvest. The highest production of stalks and sugar, in the 2006/2007 season, was obtained with the source AS. In the 2007/2008 harvest season, no residual effect of N fertilization was observed and there was a productivity decrease in the AC treatment in comparison to the control. The AC source, at a dose of 120 kg ha-1 N in the fertilization of the second ratoon, is agronomically as efficient as the other N sources used, but shows less efficiency in the subsequent crop year.