A repetitive batch process was employed followed by membrane ultrafiltration system to produce low-cost cyclodextrins (CDs) using commercial enzymes Toruzyme® cyclomaltodextrin glucanotransferase (CGTase) and its kinetic parameters were determined. The ultrafiltration system enabled the removalof inhibitory products from the reaction medium, allowing the enzyme to be recovered for reuse. A 10 kDa membrane was used to separate the different CDs produced by the CGTase. The substrates evaluated were maltodextrin, corn starch and cassava starch at 5, 10 and 15% (w/V), in the presence and absence of 10% (V/V) ethanol. After reaction for 132 h, 10% (w/V) cassava starch in the presence of ethanol provided the best results with 32.1 mg/mL of β-CD. Maximum production occurred after 72 h of reaction, with a yield of 87.4% of β-CD and an α-CD, β-CD and γ-CD production ratio of 1:1:0.08 g, respectively. When eight repetitive batches of 72 h followed by ultrafiltration and crystallization of β-CD were performed, 2.1 g of precipitate was obtained with a purity of 67.6% β-CD. The supernatant from the crystallization process was lyophilized and resulted in 35.3% α-CD. The developed model can be used industrially for the production of low cost CDs from easily obtained raw material.

<p>As farmácias de manipulação têm sido citadas por alguns atletas como sendo responsáveis pela manipulação de cápsulas contaminadas com fármacos proibidos pelo Comitê Olímpico Internacional (COI). Portanto, o presente estudo foi realizado para quantificar o montante de resíduo remanescente nos equipamentos e utensílios usados para manipular cápsulas após o procedimento padrão de limpeza. Para este propósito, o captopril (CAP) e o ácido acetilsalicílico (ASA) foram usados por serem fármacos de difícil remoção e a hidroclorotiazida (HTZ), por ser um fármaco proibido pelo COI. As quantidades de resíduos encontradas nos equipamentos após a limpeza foram 181,0 ± 91,8, 1208 ± 483,8 e 431,7 ± 71,3 ppm para ASA, CAP e HTZ, respectivamente. A manipulação contínua dos fármacos seguida pelo procedimento de limpeza mostrou acúmulo de resíduo linear para ASA (r²=0,96) e CAP (r²=0,88). A quantidade de resíduo de CAP foi maior que o limite de impureza sugerido pelo FDA (>0,1%), mas não para HTZ, mas mesmo assim, o resíduo de HTZ pode ser detectado na urina dos atletas submetidos aos testes do COI. Em conclusão, as farmácias de manipulação deveriam, portanto, melhorar o procedimentos de limpeza e testá-los para que alcancem limites abaixo de 10 ppm para evitar contaminação nos outros produtos.</p>

<p>Compounding pharmacies have been cited by some athletes as being responsible for compounding capsules contaminated with drugs banned by the International Olympic Committee (IOC). Therefore, the present study was carried out to quantify the amount of residue remaining in the equipment and utensils used for compounding capsules after standard cleaning procedures. For this purpose, captopril (CAP) and acetylsalicylic acid (ASA) were used since these are hard to clean, in addition to hydrochlorothiazide (HTZ) as a banned drug by the IOC. The amounts of residues found in the equipment were: 181.0 ± 91.8, 1208 ± 483.8 and 431.7 ± 71.3 ppm for ASA, CAP and HTZ, respectively. The continuous compounding of these drugs, followed each time by the standard cleaning procedure, showed a linear accumulation of residues for ASA (r²=0.96) and CAP (r²= 0.88). The residues quantified were greater than the FDA limit for impurities for CAP (>0.1%) but not for HTZ. However, the HTZ residue may be detected in the urine of athletes on IOC tests. Therefore, it was concluded that compounding pharmacies should therefore improve their cleaning procedures and test these in order to attain limits below 10 ppm, thereby avoiding the contamination of other products.</p>

Biospecific affinity chromatography was used to purify three cyclodextrin glycosyl transferases (CGTases) obtained from microorganisms isolated of soil. The cyclodextrins (CDs) production by CGTases was evaluated using starches from different sources. CDs were measured through the Complexation Theory and by HPLC. CGTase from Bacillus firmus strain 7B showed the best production (30 mmol/L of β-CD and 4.3 mmol/L of γ-CD), and its cultivation conditions were optimized. The maximum enzymatic activity was achieved using lung peptone, soluble starch and agitation speed of 160 rpm. Studied CGTases were shown quite interesting for the industrial production of CDs.